Liutauras Marcinauskas (Avtor), Jacob Shiby Mathew (Avtor), Mindaugas Milieška (Avtor), Mindaugas Aikas (Avtor), Mitjan Kalin (Avtor)

Povzetek

The main aim of this research was to investigate the influence of graphite as an additive to a plasma-sprayed alumina coating matrix for tribological trends. For the deposition process, pure alumina and alumina with graphite (5%, 10% and 15%) weight percentage powders were used. The graphite-modified alumina coatings were formed on steel substrates by atmospheric plasma spraying using an air-hydrogen plasma. The influence of graphite content on the elemental composition, phase structure, friction coefficient, and specific wear rate was investigated. It was obtained that the addition of graphite enhanced the γ-Al2O3 phase content in the as-sprayed coatings. The highest γ-Al2O3 phase fraction was obtained when the amount of graphite in the feedstock powders was 10 wt.%. The elemental composition results indicated that the concentration of carbon in the alumina-graphite coatings was up to six times lower in comparison to the initial feedstock, and had varied from ∼1.7 to 2.45 wt.%. The incorporation of graphite slightly reduced the friction coefficient of the composite coatings due to the formation of a self-lubricating layer under dry-sliding conditions. The specific wear rates were in the range of ∼10−6 mm3/(Nm) for the alumina-graphite composite coatings, which were similar to the alumina coating, and were an order lower compared to the wear rate of steel.

Ključne besede

plasma spraying;aluminium oxide;alumina-graphite coatings;friction;wear resistance;raman spectroscopy;

Podatki

Jezik: Angleški jezik
Leto izida:
Tipologija: 1.01 - Izvirni znanstveni članek
Organizacija: UL FS - Fakulteta za strojništvo
UDK: 531.43:539.92
COBISS: 144060931 Povezava se bo odprla v novem oknu
ISSN: 2468-0230
Št. ogledov: 6
Št. prenosov: 1
Ocena: 0 (0 glasov)
Metapodatki: JSON JSON-RDF JSON-LD TURTLE N-TRIPLES XML RDFA MICRODATA DC-XML DC-RDF RDF

Ostali podatki

Sekundarni jezik: Slovenski jezik
Sekundarne ključne besede: plazemsko pršenje;aluminijev oksid;alumina-grafitne prevleke;trenje;odpornost proti obrabi;ramanska spektroskopija;
Vrsta dela (COBISS): Članek v reviji
Konec prepovedi (OpenAIRE): 2024-02-24
Strani: str. 1-13
Zvezek: ǂVol. ǂ38
Čas izdaje: Jun. 2023
DOI: 10.1016/j.surfin.2023.102763
ID: 18187493